Antonov An-10

An-10

An Aeroflot An-10A at Monino in 1992
Role	Airliner
Manufacturer	Antonov
Designer	N. S. Trunchenkov & V. N. Ghel'prin^[1]
First flight	7 March 1957^[1]
Introduction	1959^[2]
Retired	1972
Primary user	Aeroflot
Number built	104^[1]
Developed into	Antonov An-12

The Antonov An-10 (NATO reporting name: Cat) was a four-engined turboprop passenger transport aircraft designed in the Soviet Union.^[1]

Design and development

An-10 on a 1958 Soviet postage stamp

Development of a four-engined airliner intended for use on routes from 500 to 2000 kilometers (310 to 1,262 miles) began at the end of 1955. Inspired by the Izdeliye N (Izdeliye – article or product) passenger version of the Antonov An-8 the Antonov design bureau developed the Izdeliye U ("U" for "Universal"), a four-engined aircraft with similar layout to the An-8, but with increased dimensions and a circular section pressurised fuselage.^[1] Early in the design process the choice of engines was between the Kuznetsov NK-4 and Ivchenko AI-20 and despite superior performance the Kuznetsov NK-4 was eliminated and the Ivchenko AI-20 selected partly due to the Central Committee of the Communist Party of Ukraine which wanted as much as possible produced in Ukraine, where the Ivchenko factory was.^[1]

The first prototype flew on 7 March 1957, revealing poor directional stability which led to a taller vertical fin, and later to hexagonal auxiliary fins at the tips of the tailplane. Entering production at Zavod (factory) No.64, Voronezh in 1957 the initial three aircraft were delivered with Kuznetsov NK-4 engines due to the non-availability of the Ivchenko AI-20 engines. From 1958, production aircraft were delivered with the Ivchenko AI-20A engines which boasted a longer service life and comparable performance compared to the Kuznetsov engines.^[1] The new aircraft was displayed to the public for the first time in July 1957; the design was approved for mass production after testing was completed in June 1959. Aeroflot began operations with the An-10 from 22 July 1959 on the Moscow – Simferopol route.

Configured with 85 seats, the cabin was spacious and well-appointed with comfortable seats widely spaced giving plenty of legroom, but due to the low cabin floor and wide diameter there was a lot of unusable space which limited baggage and cargo volumes. The inefficient use of cabin volume contributed greatly to the low payload/TOW ratio which was much lower than the contemporary Ilyushin Il-18, but which was still higher than the Tupolev Tu-104. A later production version, the An-10A, addressed some of the efficiency concerns by increasing the number of seats from 85 to 89 and 100 (in the two versions of the An-10A), then to 117–118 and finally 132 through reducing seat pitch and changing the cabin layout.^[1] Powered by Ivchenko AI-20K engines the An-10A demonstrated superior performance and an increased maximum payload of 14.5 Tonnes (31,970 lb). The auxiliary end-plate fins eventually gave way to improved splayed ventral fins under the rear fuselage. The directional stability was now acceptable and the new ventral fins also improved longitudinal stability at high g and on landing approach, as well as delaying the onset of Mach buffet to M0.702. Due to being sited in an area of flow separation, the new ventral fins also caused unpleasant vibrations. Following results of flight tests and at least two fatal crashes an effective tailplane de-icing system was retro-fitted to all remaining aircraft.^[1]

Operational history

A total of 104 aircraft were built, including the prototype and static test airframes, entering service with the Ukrainian Civil Aviation Directorate of Aeroflot from 27 April 1959, proving popular due to large cargo volume (when fitted with reduced seating) and excellent field performance making the aircraft suitable for use on small undeveloped airfields. The Antonov Bureau simultaneously developed and produced the Antonov An-8 medium military transport, An-10 civil airliner and military paratroop transport, as well as the Antonov An-12 military cargo transport.^[1]

On 22 April 1962 an An-10A piloted by A. Mitronin gained a world record 500 km closed loop speed record averaging 730.6 kilometres per hour (454.0 mph).^[1]

The performance of the An-10 and An-10A was relatively good and was shown to have lower seat/mile costs than the contemporary Tupolev Tu-104 jet airliner but continued to exhibit control and stability problems, culminating in a fatal crash on 16 November 1959 when CCCP-11167 dived into the ground while on approach to L'vov airport, due to reduced stability, abrupt nose drops at low airspeeds and reduced elevator authority at low airspeeds. On 26 February 1960, again at L'vov, CCCP-11180 crashed at the same location due to reduced longitudinal stability and control authority caused by icing of the tailplane.^[1]

Military use of the An-10 was fairly extensive with 45 An-10TS built for the VTA, 16 flown exclusively by military units and the remaining 38 loaned to the Ministry of Civil Aviation, as well as the flyable aircraft remaining after withdrawal from Aeroflot service.^[1]

On 18 May 1972, while descending to Kharkiv International Airport an An-10 crashed, killing 8 crew and 113 passengers. An investigation revealed fatigue cracking of the wing centre-section stringers on many of the remaining aircraft. Following this accident, Aeroflot ceased operating the An-10.^[3]

After withdrawal from Aeroflot service on 27 August 1972, 25 An-10A aircraft which were in good condition were transferred to the VVS (Soviet Air Force) and other MAP (Ministry of Aircraft Production) units.^[1] These remaining An-10As were retired by 1974.

A few examples have been preserved as exhibits in museums, and several have been converted into children's theatres (at Kiev, Samara and Novocherkassk).

Operators

Soviet Union

Variants

Izdeliye U – The in-house designation of the four-engined passenger aircraft derived from the Izdeliye N An-8 project.^[1]
An-10 – The designation of the prototype and initial production versions fitted with Kuznetsov NK-4 or Ivchenko Ai-20A engines.^[1]
An-10A – Production aircraft from December 1959 with increased seating, decreased empty weight/increased payload and Ivchenko AI-20K engines.^[1]
An-10AS – several aircraft modified for small package cargo transport with no seats.^[1]
An-10TS – (Transport/Sanitarny – transport/ambulance) 45 Aircraft ordered for the VTA (Voyenno-Transportnaya Aviatsiya – transport air arm), with 38 loaned to the Ministry of Civil Aviation.^[1]
An-10KP – (Komandny Punkt – command post) A single aircraft (CCCP-11854) modified as an airborne command post for use at Sperenburg air base, near Berlin in the DDR.^[1]

Accidents and incidents

Over its life, the An-10 experienced 12 accidents,^[4] with 370 fatalities. The An-10 carried more than 35 million passengers and 1.2 million tons of cargo, and its competitor, the Il-18 suffered from 51 fatal accidents with 1359 fatalities over the same period.

Date	Tail number	Location (all in the Soviet Union)	Casualties	Brief description
16 Nov 1959	CCCP-11167	Lviv	40/40	fell into dive on landing due to icing on wings
26 Feb 1960	CCCP-11180	Lviv	32/33	fell into dive on landing due to icing on wings
27 January 1962	CCCP-11148	Ulyanovsk	13/14	crashed on takeoff due to reversing propeller
28 July 1962	CCCP-11186	Sochi	81/81	collision into mountain due to controller error
2 August 1963	CCCP-11193	Syktyvkar	7/7	ingress of ice into engines during training flight
8 August 1968	CCCP-11172	Mirny	0/no data	ran off runway, struck a vehicle
12 October 1969	CCCP-11169	Mirny	0/no data	landed short of runway
15 May 1970	CCCP-11149	Kishinev	11/11	loss of control during training flight during simulated missed approach on two engines
8 August 1970	CCCP-11188	Kishinev	1/114	emergency landing in field due to in-flight fire
31 March 1971	CCCP-11145	Voroshilovgrad	65/65	crashed on approach due to wing separation
12 October 1971	CCCP-11137	Kishinev	no data	rough landing
18 May 1972	CCCP-11215	Kharkov	122/122	both wings fell off during landing, metal fatigue

Specifications (An-10A)

Data from Soviet Transport Aircraft since 1945^[5]

General characteristics

Crew: 5
Capacity: 100 passengers
Length: 34 m (111 ft 6.5 in)
Wingspan: 38 m (124 ft 8 in)
Height: 9.8 m (32 ft 1.75 in)
Wing area: 121.73 m² (1310.3 ft²)
Empty weight: 29,800^[6] kg (65,697 lb)
Gross weight: 55,100^[6] kg (121,473 lb)
Powerplant: 4 × Ivchenko AI-20 turboprop, 2,984 kW (4,000 hp) each each

Performance

Maximum speed: 715 km/h (444 mph)
Cruising speed: 600–660 km/h (373–410 mph)
Range: 4075 km (2532 miles)
Service ceiling: 11,000 m (36,100 ft)

References

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 Gordon,Yefim & Komissarov, Dmitry. Antonov An-12. Midland. Hinkley. 2007. ISBN 1-85780-255-1 ISBN 978-1-85780-255-9
↑ "Antonov". Aviation.ru. 2004-05-24. Archived from the original on 24 June 2006. Retrieved 2006-06-24.
↑ Gero, David (1996). Aviation Disasters Second Edition. Patrick Stephens Limited. p. 105.
↑ Aviation Safety Network Database
↑ Stroud 1968, p.63.
1 2 Gunston 1995, p. 24.

Other sources

Gordon,Yefim and Dmitry Komissarov, . Antonov An-12. Midland. Hinkley. 2007. ISBN 1-85780-255-1 ISBN 978-1-85780-255-9.
Gunston, Bill. The Osprey Encyclopedia of Russian Aircraft 1875–1995. London:Osprey, 1995. ISBN 1-85532-405-9.
Stroud, John. Soviet Transport Aircraft since 1945. London:Putnam, 1968. ISBN 0-370-00126-5.

External links

Wikimedia Commons has media related to Antonov An-10.

Airdisaster.com

Antonov aircraft

Airliners	An-10 An-24 An-28 An-74 An-140 An-148 An-158 An-174 An-180 An-218

Transports	OKA-38 An-2 An-3 An-4 An-8 An-12 An-14 An-22 An-26 An-32 An-38 An-50 An-70 An-72 An-74 An-112 An-124 An-132 An-178 An-225

Reconnaissance and surveillance	An-6 An-30 An-71 An-88

Experimental	An-13 SKV An-188

Gliders	A-1 A-2 A-7 A-9 A-10 A-11 A-13 A-15 A-40

Microlights	T-2M

This article is issued from Wikipedia - version of the 10/16/2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.